Bahia glass dilemma

Al C · Post by **Al C** » Mar 2nd, '11, 16:46

Trying replace the windshield glass on my 1973 Bahia Mar with the optional hardtop. It was not the original glass so I really don't know how it was installed from the factory or if 1/4 safety glass is what came with the boat. The ledge the glass sits in is only about 1/4 wide x 1/4 high so it leave very little room for a rubber spacers. The previous owner just siliconed the glass in place but the glass has cracked so no sense repeating his error. Any ideas on how to go about this would be greatly appreciated. Channel on the left is for the exterior trim.
Sorry for the bad picture its all I have right now.
Thanks
Al

Gert van Leest · Post by **Gert van Leest** » Mar 3rd, '11, 16:08

it is very important that the glass doesn't touch the aluminium , put rubber strips at the bottom at the sides and use sikaflex , not silicone

Good luck, Gert

CaptPatrick · Post by **CaptPatrick** » Mar 3rd, '11, 18:09

Basic Boat Window Installation

Al C · Post by **Al C** » Mar 3rd, '11, 19:54

Capt Pat
I did read your directions on window installation but with such a narrow area for my glass to sit on I thought it might not apply, not enough support? I would have approx 1/8 in. for the glass if I used 1/8 pads. Could I get by with 1/16 pads or would that be too thin?

Al

CaptPatrick · Post by **CaptPatrick** » Mar 3rd, '11, 20:12

Al,

1/16" will work, but that's pretty much minimum... Are your frames original Bertram OEM?

Al C · Post by **Al C** » Mar 3rd, '11, 20:21

Capt Pat

They look to be original but I have never seen a bahia with a hardtop close up except this one so I can't swear to it.

Al

Brewster Minton · Post by **Brewster Minton** » Mar 3rd, '11, 21:01

http://outdoors.webshots.com/photo/2414 ... 4024twrKlQ

Al C · Post by **Al C** » Mar 4th, '11, 10:36

Brewster

Is that a custom top? Looks like it could really take a pounding if it had to super sturdy looking.

Al

Brewster Minton · Post by **Brewster Minton** » Mar 4th, '11, 11:35

It is custom. Was put on by a pinhooker out of New London. Way better than canvas and zippers when the s$#t hits the fan.

killa · Post by **killa** » Mar 5th, '11, 08:32

ac I have a 69 with sliding windows does yours {with hard top}windshield is now fixed use to open r u changing the windshield also.i am looking 4 tips also.

Al C · Post by **Al C** » Mar 5th, '11, 11:11

Killa

My side windows slide but the front has fixed glass. Still not sure what I am going to do, there are several custom window makers out there but that would entail modifying the frames and I am not real comfortable with that. At one point I was thinking of removing the top and going with a windshield and updated hardtop but that looks like 10-15k. At this point I think replacing the glass would be the best solution if done correctly, after all its been there for almost 40 yrs.

Al

bertram31.com

Bahia glass dilemma

Bahia glass dilemma

bahia windows

Who is online